Know More

Blast Furnace Coke Properties and - Know More

blast furnace the reaction was limited by the diffusion rate Coke degradation was therefore mostly restricted to the coke surface in the blast furnace At a later EBF campaign, off-gas dust was sampled during operation with different iron-bearing materials EBF process data were used to evaluate the relationship...

Quality Improvement of Sintered Ore in Relation to Blast , - Know More

As a result, the blast furnace attained a productivity coefficient as high as 237 t/d/m3 and a high ore/coke rate of 487 with a PCR of 161 kg/t-pig11 32 Improvement of blast furnace operation by decreasing Al2O3 content in sinter Further extending the line of the above tests, in 2001 another series of tests were conducted for decreasing ....

Use of Nut Coke In a Blast Furnace - Know More

Dec 02, 2017 0183 32 Use of Nut Coke In a Blast Furnace , BF profitability increments by 15 to 25 when utilizing 10 to 20 weight percent of nut coke to BF coke rate , Blending nut coke in the sinter ,...

Iron Ore Sintering Part 2 Quality Indices And Productivity - Know More

Iron Ore Sintering Part 2 Quality Indices And Productivity , furnace coke rate by 14 kg t-1 , The main cause of blast furnace dust and the sintering ESP dust promoted the emission of SO2 and ....

Application of High Ratio Coke Mixed Charging Technique to , - Know More

blast furnace operation in the future Ore-coke mixed charging, in which coke is mixed in the sinter or iron ore raw material and charged into the blast furnace, is known as one technique for achiev-ing these objectives1,2 Although this is a technique which improves the permeability and reducibility of...

Why sinter is used in blast furnace - Know More

By convention, this excludes coke nut/pearl coke mixed with sinter etc Introduction of high quality coke to a blast furnace will result in lower coke rate, higher productivity and lower hot ....

913 Alumina in Blast Furnace/Corex Burden - Know More

slag rate, reduced output and increased energy consumption through coke rate Based on the above study, correlation of Alumina in Sinter with Blast Furnace carbon rate was conducted As per the study, every 1 increase of Alumina in BF burden, carbon rate in Blast Furnaces ,...

What is coke rate in blast furnace - Know More

Jan 17, 2012 0183 32 According to steelnicin Coke Rate is measured in Kgs of BF Coke consumed per tonne of Hot Metal produced in the Blast Furnace Kg/THM By convention, this excludes coke nut/pearl coke,...

Blast Furnace Operation - Know More

The sintering process begins with the preparation of a sinter mixture consisting of iron ore fines, fluxes, solid fuel called bonding agents in Japan such as coke breeze, and return fines from the sinter plant and blast furnace as well as recycled ferruginous materials ,...

percentage of iron,coke,sinter and pellet in blastfurnace , - Know More

Factors affecting Coke rate in a Blast Furnace , Factors affecting Coke rate in a Blast , The process of iron making in a blast furnace consists of a , During the production of hot metal in a blast furnace, , Get Price iron ore pellet consumption percentage blast , percentage of iron,coke,sinter and pellet in blastfurnace ....

75 questions with answers in Blast Furnace Science topic - Know More

Dec 03, 2019 0183 32 O/C ration in blast furnace decides the gas permeability inside the blast furnace There should be minimum coke layer thickness which ensure the ,...

Blast Furnace operation Thermal Control - Know More

Aug 03, 2011 0183 32 If the hot blast temperature is lower than the aim for more than 4 hours then a fuel rate equivalent change is to be made to restore the thermal input However if by reducing the blast moisture results in a flame temperature above 2250˚C then the coal rate or coke rate should be increased instead...

Pellet Degradation Effect on Blast Furnace Performance - Know More

From the blast-furnace test, carried out with a burden consisting of 45 of pellets and 45 of sinter with basicity ratio about 22, and at constant driving rate, it follows that there is no significant relationship between the disintegration value of the pellets and the blast-furnace permeability...

Why is sinter used in a blast furnace? - Know More

Aug 10, 2017 0183 32 During the extraction of hematite ore mining , very small sized iron particles are obtained If particles of such sizes are directly used in the blast furnace for obtaining iron, they would choke the tuyeres and may even cause explosion inside th....

UDC 622 785 5 669 162 26 012 4 Quality , - Know More

viscosity of the blast furnace slag were adequately maintained by composition control without top charging of lump flux Case 2 of Table 1 As a result, the blast furnace attained a productivity coef-ficient as high as 237 t/d/m3 and a high ore/coke rate of 487 with a PCR of 161 kg/t-pig11 32 Improvement of blast furnace operation by ....

UDC 669 162 263 Inner Profile and Burden Descent , - Know More

Sinter Sinter coke coke Fig 6 Relationship between wall erosion condition and particle descent behavior at the upper shaft sinter 1-3mm / 05-1mm = 80/20, coke 4-6mm , gas utilization rate in the entire blast furnace increased 15 In addi-tion, the consumption of reducing agent rate ,...

Fuel Economy Index as a Criterion for Reduction of Coke , - Know More

Fuel Economy Index as a Criterion for Reduction of Coke Rate in the Blast Furnace PO Sun Jvala , percenl sinter in burden limestone rate slag vo lume, wind vo lume wind pressure, etc hLtl lie , Sunaval i had indicated that the coke rate in the blast furnace could be lowered by oxygen enrichment of the blast, but this coke economy was...

Recent Progress in Ironmaking Technology for 2 Mitigation , - Know More

coke breeze is used as a bonding agent for sinter, and lump coke is charged to the blast furnace The coke oven gas C gas and blast furnace gas B gas generated by the coke ovens and blast furnace are used as fuels in various ironmaking processes sintering, coke ovens, hot stove, power plant , or are injected into the blast furnace...

Relationship between sinter properties and iron ore , - Know More

sinters were characterised by chemical analysis, degradation during reduction in the blast furnace reduction degradation index test , cold strength tumbler test , coke consumption and process productivity Sinter quality was assessed in relation to the granulation index of the ore mixture...

What is the purpose of coke in a blast furnace? AnswersDrive - Know More

The purpose of a blast furnace is to chemically reduce and physically convert iron oxides into liquid iron called hot metal The blast furnace is a huge, steel stack lined with refractory brick, where iron ore, coke and limestone are dumped into the top, and preheated air is blown into the bottom...

relationship of sinter in blast furnace coke rate - Know More

UDC 669 162 2 Development of Ironmaking Technology of phenomena in the lower part of a blast furnace including the behavior of particulate substances , quality control of sinter and coke such as a sintering method for lowering SiO 2 content and blast furnace evaluation technology, etc , 3 Use of plastics as the alternative energy source for blast furnaces and coke ovens....

Technical Progress of Blast Furnace Ferromanganese , - Know More

Technical Progress of Blast Furnace Ferromanganese Production in China Zhang Tangke Dianxin Ferromanganese Factory, Kunming, Yunnan, China , limestone was replaced by the quicklime with coke rate reduced 21 , Xinggang Corporation added all dolomite into the sinter mixture instead of directly into the Blast Furnace The Mn sinter produced ....

Sinter Plant Process - Know More

Sinter Plant Industrial Efficiency Technology ?/h3 gt Learn more » The purpose of the sinter plant is to process fine grained raw materials into a coarse grained iron ore sinter, ready to be charged to the blast furnace...

What is sinter feed? AnswersDrive - Know More

Sinter plants agglomerate iron ore fines dust with other fine materials at high temperature, to create a product that can be used in a blast furnace The final product, a sinter, is a small, irregular nodule of iron mixed with small amounts of other minerals...

Why is sinter used in a blast furnace? - Know More

Aug 09, 2017 0183 32 During the extraction of hematite ore mining , very small sized iron particles are obtained If particles of such sizes are directly used in the blast furnace for obtaining iron, they would choke the tuyeres and may even cause explosion inside th....